BMW MINI COUNTRYMAN UK Recall Check

---

Recalls Number (Vehicles Effected)

R/2022/256 (17921)

Manufacturer Reference

0013700300-MINI (B47O B47U)

Defect

Undetected EGR System leaks may cause thermal activity in the intake manifold.

Remedy

The engine management control unit (DDE) will be programmed with improved software incorporating the latest OBD functionality.

---

Recalls Number (Vehicles Effected)

R/2020/290 (627)

Manufacturer Reference

0061650500

Defect

A possibility of impurities contained in the HV batteries may cause short circuit.

Remedy

Testing of battery charge cycles and replacement of the HV cells where necessary.

---

Recalls Number (Vehicles Effected)

R/2020/299 (74)

Manufacturer Reference

0061530500 0061550500

Defect

In very rare cases welding beads were not always completely removed in the cleaning process during battery production.

Remedy

Test and replace the High Voltage batteries if affected.

---

Recalls Number (Vehicles Effected)

R/2020/179 (71128)

Manufacturer Reference

0011720500 0011740500

Defect

The Exhaust Gas Recirculation (EGR) Module cooler could leak over time

Remedy

The EGR cooler will be inspected on the affected vehicles and replaced if evidence of leaking is found.

---

Recalls Number (Vehicles Effected)

R/2020/136 (161)

Manufacturer Reference

0072140200502006020070200

Defect

Curtain airbags may have propellant which may have a humidity level higher than specification and in the event of a collision may not deploy correctly increasing the risk of injury.

Remedy

Replace the airbags on affected vehicles.

---

Recalls Number (Vehicles Effected)

R/2019/288 (19)

Manufacturer Reference

0032890200 0032900200

Defect

The steering gear tie rod may not have been assembled with a required spherical washer

Remedy

Both steering gear tie rods will be checked and if affected tie rod/s and accompanying swivel bearing/s will be replaced

---

Recalls Number (Vehicles Effected)

R/2018/260 (1642)

Manufacturer Reference

"001392020000013810200/20200"

Defect

The affected vehicles may be equipped with a crankshaft sensor with a software fault.

Remedy

On the affected vehicles the crankshaft sensor will be replaced with a new version.

---

Recalls Number (Vehicles Effected)

R/2018/242 (7132)

Manufacturer Reference

0013900200

Defect

A crash protection plate for the high pressure fuel pump was not installed in 3-cylinder petrol engines.

Remedy

On the affected vehicles the crash protection plate will be retrofitted.

---

Recalls Number (Vehicles Effected)

R/2018/211 (4025)

Manufacturer Reference

"0013850200 0013860200"

Defect

The affected vehicles may be equipped with a crankshaft sensor with a software fault. The crankshaft sensor cannot process the signal values from the crankshaft transmitter due to an improper firmware level. The firmware does not compensate sufficiently the temperature gradients and the magnetic field strength of the sensor electronic. If the crankshaft sensor cannot process the signal values from the transmitter the Digital Diesel Electronic (DDE) will notice that and change to the emergency operation mode. The emergency mode will be displayed by the check control message ?engine malfunction?. The driver may notice a rough running engine and a reduced driving power (70%). However an engine stalling during driving conditions cannot be excluded.

Remedy

On the affected vehicles the crankshaft sensor will be replaced with a new version.

---

Recalls Number (Vehicles Effected)

R/2018/171 (100)

Manufacturer Reference

0031850100 0031860100

Defect

"Due to a fault in the supplier production process the swivel bearings on the front axle of the affected vehicles may not have been produced to specification. Due to an insufficient heat treatment the fracture strain has been reduced. The affected swivel bearings could break causing loss of wheel guidance during driving. "

Remedy

On the affected vehicles both swivel bearings will be checked and if necessary replaced with a part produced to specification.