HYUNDAI I30 UK Recall Check

---

Recalls Number (Vehicles Effected)

R/2022/164 (210)

Manufacturer Reference

11DC45

Defect

The subject vehicles may experience abnormal performance of the front right hand seatbelt pretensioner during deployment.

Remedy

Replace the front right hand seatbelt assembly with a countermeasure part.

---

Recalls Number (Vehicles Effected)

R/2020/059 (9191)

Manufacturer Reference

01D010

Defect

When the vehicle is turned off if moisture enters the ABS module it could cause an electrical short.

Remedy

Affected vehicles will have a relay installed in the main fuse box to prevent power going to the ABS module when the ignition key is in the off position.

---

Recalls Number (Vehicles Effected)

R/2020/016 (9200)

Manufacturer Reference

91C080

Defect

In the event of an impact on the lower part of the vehicle body the airbag may prematurely deploy

Remedy

The airbag Control Unit will be reprogrammed

---

Recalls Number (Vehicles Effected)

R/2019/055 (11)

Manufacturer Reference

81C095

Defect

The sunroof anti-pinch function may not work properly.

Remedy

The sunroof and roller blind motors will be checked and if necessary replaced with an improved part.

---

Recalls Number (Vehicles Effected)

R/2019/055 (11)

Manufacturer Reference

81C095

Defect

The sunroof anti-pinch function may not work properly.

Remedy

The sunroof and roller blind motors will be checked and if necessary replaced with an improved part.

---

Recalls Number (Vehicles Effected)

R/2015/056 (12512)

Manufacturer Reference

Defect

Two LEDs are used to calculate torque applied to the steering wheel. If the ECU senses a discrepancy in the torque sensing circuitry an indicator lamp is illuminated in the instrument cluster a diagnostic code is stored and steering assist is no longer provided. The driver will have to supply more effort to steering the vehicle.

Remedy

Recall the vehicles that are likely to be affected and re-programme the steering ECU. The steering will then be tested. If the vehicle fails the test a new torque sensor will be fitted.

---

Recalls Number (Vehicles Effected)

R/2014/128 (5267)

Manufacturer Reference

41C055

Defect

Whilst manoeuvring a noise can be heard from the lower steering column area. The cause has been identified as loose bolts on the column universal joint. In extreme cases these may drop out causing the universal joint to detach and failure of the steering

Remedy

Check column for correct fitting and tighten universal joint bolts to correct torque.

---

Recalls Number (Vehicles Effected)

R/2014/128 (5267)

Manufacturer Reference

41C055

Defect

Whilst manoeuvring a noise can be heard from the lower steering column area. The cause has been identified as loose bolts on the column universal joint. In extreme cases these may drop out causing the universal joint to detach and failure of the steering

Remedy

Check column for correct fitting and tighten universal joint bolts to correct torque.

---

Recalls Number (Vehicles Effected)

R/2013/020 (2632)

Manufacturer Reference

21C035

Defect

On Some i30 (GD) vehicles fitted with a manual transaxle after applying the parking brake it may not fully release after releasing it. This is due to corrosion where water is entering into rear caliper.

Remedy

The parking brake mechanism must be inspected if it is free of corrosion a new seal must be fitted and then the cable lever kit must be replaced. If corrosion is visible both rear brake calipers must be replaced.