JEEP CHEROKEE UK Recall Check

---

Recalls Number (Vehicles Effected)

R/2023/196 (149)

Manufacturer Reference

45A

Defect

On affected vehicles relative movement between the differential input splines and the transmission output shaft in the area of the power transfer unit?wear of the input splines?cannot?be?ruled?out.?

Remedy

Reprogram of the Drive Train Control Module and Electric Park Brake.

---

Recalls Number (Vehicles Effected)

R/2021/029 (261)

Manufacturer Reference

W47

Defect

A possible loss of motive power or PARK function due to wear in the Power Transfer Unit.

Remedy

Reprogram the Drive Train Control Module and Electric Park Brake.

---

Recalls Number (Vehicles Effected)

R/2018/189 (80)

Manufacturer Reference

U63

Defect

"A short in the vehicle causing the CAN-C bus to stop communicating while the cruise control is active and the vehicle speed is below the set speed such that the cruise control system is requesting positive torque at the exact moment of the short it is possible for a positive torque request to be locked on the PCM. This may result in either the vehicle maintaining its current speed or possibly accelerating."

Remedy

Inspect the software level of the Powertrain Control Module (PCM) and if necessary reprogram the PCM

---

Recalls Number (Vehicles Effected)

R/2018/202 (56)

Manufacturer Reference

U38

Defect

"The rear lower control arms may experience excessive corrosion eventually resulting in a fractureA fractured rear control arm could cause reduced vehicle control and can cause a vehicle crash without prior warning"

Remedy

Replace both rear lower control arms

---

Recalls Number (Vehicles Effected)

R/2017/056 (1418)

Manufacturer Reference

S55

Defect

The transaxle wiring harness may have been built with insufficient wire terminal crimp(s). This may cause the transmission to select neutral.

Remedy

Reprogram the Powertrain Control Module (PCM) and the Transmission Control Module (TCM). Where necessary the transaxle range sensor wire harness replaced.

---

Recalls Number (Vehicles Effected)

R/2016/288 (30)

Manufacturer Reference

S63

Defect

Front and/or rear seats may have been fitted with incorrectly tightened fasteners. This may increase risk of injury to occupants during a collision.

Remedy

Replace affected seat assemblies.

---

Recalls Number (Vehicles Effected)

R/2016/163 (17)

Manufacturer Reference

S36

Defect

The Body Control Module (BCM) may have incorrect headlamp levelling parameters. This can result in headlamp levelling switch operation being the opposite of the headlamp directional movement desired. This could cause a crash without warning.

Remedy

Recall the vehicles that are likely to be affected and the headlamp levelling parameters will be reprogrammed within the BCM.

---

Recalls Number (Vehicles Effected)

R/2016/021 (14551)

Manufacturer Reference

R06

Defect

The Occupant Restraint Control (ORC) module may allow a front airbag and/or seatbelt pretensioner to inadvertently deploy.

Remedy

On affected vehicles replace the ORC Module. Due to issues with parts supply the recall of WG/WJ models is suspended however KJ models remain unaffected.

---

Recalls Number (Vehicles Effected)

R/2016/026 (1115)

Manufacturer Reference

R67

Defect

Water intrusion into the power liftgate module electrical connectors can lead to corrosion and higher resistance. This condition can cause the module to become inoperative and/or cause a fire.

Remedy

Recall the vehicles that are likely to be affected. The vehicles will be inspected for evidence of water intrusion and electrical connector corrosion. The vehicle will be repaired to eliminate the possibility of further water intrusion. On vehicles found with corrosion in the power liftgate module electrical connectors the module and electrical connectors will be replaced. All the vehicles will receive a power liftgate module water shield.

---

Recalls Number (Vehicles Effected)

R/2015/218 (2201)

Manufacturer Reference

R27

Defect

Due to water ingress the tailgate power module may develop a short circuit. This may cause the module to fail and in extreme cases

Remedy

Check affected vehicles for water ingress and modules for corrosion. Where necessary rectify water ingress replace power module and connectors and fit a power module water shield

---

Recalls Number (Vehicles Effected)

R/2015/192 (988)

Manufacturer Reference

R13

Defect

The clutch interlock switch may be faulty. This could allow starting of the engine without depressing the clutch pedal and with the transmission engaged.

Remedy

On affected vehicles replace the clutch interlock switch.

---

Recalls Number (Vehicles Effected)

R/2014/166 (206)

Manufacturer Reference

P37

Defect

"One or more of the rear suspension shock absorbers may break at one of the shock absorber attachment points. A partially detached rear suspension shock absorber(s) could cause damage to other rear chassis/suspension components rear brake pipe damage and/or damage to the rear tyre/s increasing the risk of a crash."

Remedy

Check date code of shock absorber fitted and where applicable replace shock absorber

---

Recalls Number (Vehicles Effected)

R/2013/093 (33053)

Manufacturer Reference

N45 & N46

Defect

If the vehicle is involved in a rear end collision then it is possible that the fuel tank could be damaged. This can then result in a fuel leak which if in the presence of an ignition source then a vehicle fire could ensue.

Remedy

---

Recalls Number (Vehicles Effected)

R/2014/080 (20)

Manufacturer Reference

P31

Defect

The Cruise Control may cause unintended continued vehicle acceleration after an accelerator pedal override manoeuvre. As a result when the Cruise Control is set and the driver presses the accelerator pedal to accelerate more than the Cruise Control system would on its own; The vehicle may continue to accelerate briefly after the accelerator pedal is released.

Remedy

Reprogramme the Adaptive Cruise control (ACC) Module with new software

---

Recalls Number (Vehicles Effected)

R/2013/120 (14558)

Manufacturer Reference

M35

Defect

The Occupant Restraint Control (ORC) Module may experience a very high voltage spike which may result in the inadvertent deployment of the front airbags and/or the seatbelt pretensioner. This could result in the loss of control of the vehicle.

Remedy

Recall all the affected vehicles for the fitment of a filter harness for the ORC module.

---

Recalls Number (Vehicles Effected)

R/2010/219 (23)

Manufacturer Reference

K24

Defect

The windscreen wiper motor may fail without warning. This could result in a reduction of the driver's visibility under certain operating conditions and ultimately cause a collision.

Remedy

Recall all affected vehicles for the replacement of the wiper motor.

---

Recalls Number (Vehicles Effected)

R/2010/105 (1707)

Manufacturer Reference

J17

Defect

The upper control arm ball joints fitted to the nearside and/or offside front suspension may experience a loss of lubricant which can lead to corrosion accelerated wear and separation whilst driving. If the ball joint separates directional control will be lost.

Remedy

The recalled vehicles will have new front suspension upper control arms fitted the front suspension.

---

Recalls Number (Vehicles Effected)

R/2006/150 (3300)

Manufacturer Reference

F20

Defect

It has been identified that the wireless control module may fail with the result that the engine may fail to start or cut out.

Remedy

Recalled vehicles will have the wireless control module replaced.

---

Recalls Number (Vehicles Effected)

R/2004/016 (7129)

Manufacturer Reference

C36

Defect

Water may enter the front suspension ball joints this can cause the ball joint to corrode and separate.

Remedy

Replace any corroded ball joints and fit dirt/water shields to all vehicles.

---

Recalls Number (Vehicles Effected)

R/2003/020 (1848)

Manufacturer Reference

B31

Defect

Vehicles may experience a loss of power assistance to the brakes due to a collapsed brake booster vacuum hose. This will result in increased effort being required from the driver to apply the foot brake.

Remedy

Inspect the brake booster vacuum hose. If damaged the hose will be replaced. In either case the hose will be re routed to eliminate interference with the coolant recovery pipe.

---

Recalls Number (Vehicles Effected)

R/2003/019 (2552)

Manufacturer Reference

B30

Defect

Vehicles may experience a vacuum leak in the EGR to Electronic Vacuum Regulator (EVM) tube. This may cause a loss of brake booster vacuum and require increased effort from the driver to operate the foot brake.

Remedy

Inspect the vacuum tube from the EVM to the dash panel. Replace if damaged and re route the tube to eliminate interference with the exhaust shield.

---

Recalls Number (Vehicles Effected)

R/2002/116 (7143)

Manufacturer Reference

B10

Defect

The steel vacuum tube that supplies vacuum to the brake booster may crack resulting in loss of servo assistance. This will result in increased pedal power to stop the vehicle.

Remedy

Recall vehicles and replace the steel vacuum tube with a flexible vacuum hose.

---

Recalls Number (Vehicles Effected)

R/2001/166 (44314)

Manufacturer Reference

0A05

Defect

There is a possibility that corrosion may cause the front brake rotors (Discs) to separate from the centre hub section. Vehicle may pull to one side when braking. Also braking efficiency will be reduced.

Remedy

Recall affected vehicles for inspection and if necessary replacement of both front brake rotors with new version. ( Note. Some vehicles will already have the new version fitted)

---

Recalls Number (Vehicles Effected)

R/2001/156 (404)

Manufacturer Reference

Defect

The lower instrument panel cover may have been incorrectly installed. This could lead to the cover becoming detached and distract the driver.

Remedy

A revised instrument panel will be fitted that is equipped with wire hooks.

---

Recalls Number (Vehicles Effected)

R/2000/069 (11209)

Manufacturer Reference

860

Defect

The Airbag control module may corrode internally due to water intrusion. Internal corrosion could cause illumination of the Airbag warning light or cause the Airbags to deploy without warning.

Remedy

Recall affected vehicles and replace Airbag control module with a modified type.

---

Recalls Number (Vehicles Effected)

R/1998/070 (9206)

Manufacturer Reference

Defect

The fuel tank level sending unit may cause the fuel gauge to display an inaccurate fuel level. As a result the vehicle may run out of fuel when the gauge still indicates that there is fuel remaining in the tank.

Remedy

Recall all affected vehicles and fit a quality assured fuel tank sender unit.

---

Recalls Number (Vehicles Effected)

R/1998/036 (157)

Manufacturer Reference

Defect

The brake booster diaphragm on affected vehicles may split or rupture causing a loss of brake power assistance. This can result in increased effort being required at the brake pedal.

Remedy

Recall the affected range of vehicles examine the power brake booster and replace if necessary.

---

Recalls Number (Vehicles Effected)

R/1998/043 (20)

Manufacturer Reference

Defect

The front shoulder belt adjustable anchors on affected vehicles may have been improperly manufactured and could have inadequate strength. An anchor with inadequate strength may allow the front shoulder belt to separate from the anchor under certain accident conditions.

Remedy

To correct this condition both front shoulder belt adjustable anchors must be replaced.

---

Recalls Number (Vehicles Effected)

R/1996/060 (349)

Manufacturer Reference

Defect

The fasteners securing the alternator circuit fuse to the power distribution centre may not be correctly clamped. This could result in arcing at the connection with a possibility of an under bonnet fire.

Remedy

Recall the affected vehicles for replacement of the power distribution centre fuse with a fuse link.