PEUGEOT EXPERT UK Recall Check

---

Recalls Number (Vehicles Effected)

R/2023/140 (29537)

Manufacturer Reference

MF9/221078CO

Defect

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.?

Remedy

Reprogram the Powertrain Diagnosis ECU with updated software.

---

Recalls Number (Vehicles Effected)

R/2023/079 (4)

Manufacturer Reference

MFA/230221EE

Defect

Affected vehicles may have a steering tie rod/track rod end nut that has not been tightened to the correct torque.

Remedy

Replace the steering tie rod/track rod end nut and tighten to the correct torque.

---

Recalls Number (Vehicles Effected)

R/2022/338 (2231)

Manufacturer Reference

MBM

Defect

Some vehicles may have been equipped with an incorrectly positioned fuel pipe.?

Remedy

Check fuel pipe positioning correct if necessary and fit protective sleeve.?

---

Recalls Number (Vehicles Effected)

R/2019/438 (4485)

Manufacturer Reference

JUV

Defect

"The tightening and positioning of the seat belt lower bolts may be incorrect."

Remedy

This campaign consists of checking and if necessary correcting both the position of the bolt and the tightening torque of all of the lower fixings of the seat belts.

---

Recalls Number (Vehicles Effected)

R/2020/070 (916)

Manufacturer Reference

JVB

Defect

Possible non-conformity of certain seals in the front wheel arches could lead to water ingress into the passenger compartment.

Remedy

Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required.

---

Recalls Number (Vehicles Effected)

R/2019/433 (134)

Manufacturer Reference

JUT

Defect

A non-conformity of the rear brake callipers could reduce the efficiency of the parking brake.

Remedy

Check and if necessary replace the callipers

---

Recalls Number (Vehicles Effected)

R/2019/431 (22882)

Manufacturer Reference

Defect

The fuel pipes under the body may have been damaged over time due to a relative movement between these pipes and their surroundings.

Remedy

Check the condition of the fuel pipes and replacing them if necessary. New protection will be fitted on all vehicles to prevent this damage in the future.

---

Recalls Number (Vehicles Effected)

R/2019/425 (21217)

Manufacturer Reference

JTS

Defect

The rear brake hoses may have been damaged over time due to inappropriate movement between these hoses and a clip.

Remedy

Check the condition of the rear left-hand and right-hand brake hoses and replacing them if necessary. A new retaining clip is fitted on all vehicles to prevent this relative movement.

---

Recalls Number (Vehicles Effected)

R/2020/078 (1)

Manufacturer Reference

JUE

Defect

The tightening of some rear suspension fixings may not be correct to specification.

Remedy

Correcting some tightening torques and replacing some nuts and bolts.

---

Recalls Number (Vehicles Effected)

R/2019/435 (127)

Manufacturer Reference

JUU

Defect

The tightening of the seat belt fixings and of certain earth cables may not conform to specification

Remedy

Tightening of the seat belt fixings and of certain earth cables.

---

Recalls Number (Vehicles Effected)

R/2020/092 (4)

Manufacturer Reference

JRH

Defect

There is a possibility that the rear brake hose may become damaged due to relative movement between the hose and the holding clip.

Remedy

Check the condition of the left and right rear brake hoses and replace them if necessary.

---

Recalls Number (Vehicles Effected)

R/2019/429 (3)

Manufacturer Reference

JTC

Defect

Certain seals in the front wheel arches may not be correct to specification and may cause water ingress into the passenger compartment

Remedy

Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required

---

Recalls Number (Vehicles Effected)

R/2017/074 (5)

Manufacturer Reference

HPX

Defect

The tightening torque of one of the nuts of the connection between the brake servo unit and the brake pedal may be not correct to specification. This may allow air to enter the servo

Remedy

Check servo security and where necessary replace the brake servo unit

---

Recalls Number (Vehicles Effected)

R/2017/072 (2)

Manufacturer Reference

HPW

Defect

Incorrect assembly of the steering rack which could cause the loss of the mechanical link between the steering pinion valve and the steering rack during parking manoeuvres at full lock.

Remedy

Check affected vehicles and where necessary replace the steering rack.

---

Recalls Number (Vehicles Effected)

R/2017/068 (100)

Manufacturer Reference

HNW

Defect

It has been identified that due to a possible non-conformity of certain seals on the vehicle?s body there is the possibility that water can enter the passenger compartment of the vehicle. The occupants should experience either wet carpets and or a possible damp smell. However the ingress of water into the cabin could affect the electrical operation of the airbag module which could lead to an unexpected deployment of the airbag.

Remedy

Recall all affected vehicles to add additional sealant to the body interfaces and if required to replace any interior components damaged by the water ingress.

---

Recalls Number (Vehicles Effected)

R/2017/059 (2)

Manufacturer Reference

HPU

Defect

The bolts retaining the front shock absorber could come loose. This may adversely affect the steering control of the vehicle.

Remedy

On affected vehicles replace the front shock absorber retaining bolts.

---

Recalls Number (Vehicles Effected)

R/2017/061 (1312)

Manufacturer Reference

HQA

Defect

On the affected vehicles a possible nonconformity of certain seals on the vehicle?s body could lead to water ingress in the passenger compartment. This may affect the operation of the passenger air bag. Unintended deployment is possible.

Remedy

On affected vehicles add extra sealant and replace wet or water damaged components.

---

Recalls Number (Vehicles Effected)

R/2016/172 (797)

Manufacturer Reference

HJN

Defect

On affected vehicles the driver's air bag inflation device may not conform to specification. As a result may not deploy correctly during an impact.

Remedy

Replace the driver's air bag module on affected vehicles

---

Recalls Number (Vehicles Effected)

R/2014/161 (2713)

Manufacturer Reference

ZUB

Defect

On affected vehicles; Under certain conditions the fuel leak off pipe may become insecure at the connection to the injector. If this happens fuel may leak form the connection. Fuel may accumulate in the engine compartment and vehicle users will be aware of a smell of fuel.

Remedy

Inspect connection on affected vehicles and where necessary replace the fuel leak off return pipe fixing with new adhesive.

---

Recalls Number (Vehicles Effected)

R/2014/003 (54)

Manufacturer Reference

ZMW

Defect

On certain vehicles the front brake discs may not be the required thickness for the vehicle definition. This concern may result in reduced braking efficiency.

Remedy

Recall the vehicles that are likely to be affected to check and where necessary replace the front brake discs.

---

Recalls Number (Vehicles Effected)

R/2014/002 (446)

Manufacturer Reference

ZMP &ZNJ

Defect

An internal fault with the wiper motor could cause it to stop working. In some rare cases the windscreen wipers may stop working while in operation.

Remedy

Recall affected vehicles and check the manufacturing date of the wiper motor and add a supplementary earth wiring harness if necessary.

---

Recalls Number (Vehicles Effected)

R/2013/096 (71)

Manufacturer Reference

ZLF

Defect

The steering column link bolt which retains the steering wheel to the steering column may not have been tighten to the correct specification. This can result in a gradual increase in movement between the steering wheel and shaft with an associated rattle. This should identify the issue to the driver however if the driver does not heed this warning then the steering control of the vehicle could be reduced.

Remedy

Recall all affected vehicles to check and if required re-torque the steering column link bolt.

---

Recalls Number (Vehicles Effected)

R/2012/041 (14)

Manufacturer Reference

ZEJ

Defect

Some tyres may have suffered superficial damage when the vehicle was being transported. The front Left hand tyre may have localised damage on the tread or the inner side. The tyre may rip and deflate.

Remedy

Carry out a visual check of the condition of the tyre in the affected areas and replace the tyre if necessary.

---

Recalls Number (Vehicles Effected)

R/2011/141 (4)

Manufacturer Reference

ZBP

Defect

In rare cases on the concerned engines a possible manufacturing nonconformity of the cylinder head may lead to an oil leak.

Remedy

Check and replace cylinder head.

---

Recalls Number (Vehicles Effected)

R/2011/083 (1577)

Manufacturer Reference

ZAM

Defect

It is possible that the wiring harness for the power assisted steering motor may come in contact with other components in the engine bay. Should this occur then it is possible that the power steering assistance on this large vehicle may become affected.

Remedy

Recall affected vehicles and fit protection to the wiring harness.

---

Recalls Number (Vehicles Effected)

R/2011/017 (2834)

Manufacturer Reference

YYW

Defect

On some 2.0 l HDI vehicles potential contact between the fuel return pipe and the diesel filter support may eventually cause the pipe to become worn through friction.

Remedy

The manufacturer has requested that some protection be added to the pipe to ensure its long-term resistance to wear.

---

Recalls Number (Vehicles Effected)

R/2010/222 (24220)

Manufacturer Reference

YWY

Defect

In very rare circumstances the vacuum pump one way valve may not function correctly which could affect the level of braking assistance.

Remedy

Recall the vehicles that are likely to be affected to replace the brake vacuum pump one way valve.

---

Recalls Number (Vehicles Effected)

R/2010/157 (2903)

Manufacturer Reference

YWB

Defect

It has been identified that the position of the exterior lighting control ring may not be detected by the lighting management system and the lights may switch off without warning.

Remedy

Recalled vehicles will have the lighting management software updated.

---

Recalls Number (Vehicles Effected)

R/2010/114 (386)

Manufacturer Reference

YWR

Defect

The threaded portion of the brake linkage rod in the brake control system may not be to conformity. This could result in a reduction of braking efficiency.

Remedy

Recall affected vehicles to check rod and replace if found not to meet conformity.

---

Recalls Number (Vehicles Effected)

R/2010/029 (2001)

Manufacturer Reference

YTQ

Defect

It has been identified that water may ingress the brake drums causing premature brake lining wear. Should this occur the brake effort produced by the rear wheels may be reduced.

Remedy

Recalled vehicles will have a seal fitted to the handbrake cable and the subject brake linings replaced.

---

Recalls Number (Vehicles Effected)

R/2010/016 (2611)

Manufacturer Reference

YTT

Defect

It has been identified that the possibility exists that contact between the fuel return pipe and the engine shield may take place inside the engine compartment. Should this occur wear on the pipe would ensue which in the worst case; would result in a fuel leak.

Remedy

Recalled vehicles will be fitted with an additional fastener to ensure that contact is not made and if necessary the fuel return pipe will be replaced.

---

Recalls Number (Vehicles Effected)

R/2009/104 (48938)

Manufacturer Reference

YSC

Defect

In rare cases the lighting management system may incorrectly detect the lighting switch ring position which may cause the lights to cut out.

Remedy

Recall affected vehicles and download new version of vehicle exterior lighting software

---

Recalls Number (Vehicles Effected)

R/2008/183 (290)

Manufacturer Reference

Defect

The throttle pedal may not return to its initial position as a result of a nonconformity to specification.

Remedy

Recall the vehicles that are likely to be affected to check and where necessary replace the pedal mechanism.

---

Recalls Number (Vehicles Effected)

R/2008/015 (19867)

Manufacturer Reference

YNMYNLYMKYMJYKLYFQ

Defect

It has been identified that on the specified vehicles a fault may develop with the brake vacuum pump. This can result in hardening of the brake pedal with an attendant loss of braking efficiency.

Remedy

Recalled vehicles will have the vacuum pump replaced.

---

Recalls Number (Vehicles Effected)

R/2007/148 (749)

Manufacturer Reference

YGC

Defect

It has been identified that the earthing terminal for the electrical power assisted steering assembly may require reinforcing. This is necessary in order to provide the correct electrical supply to the power steering assembly and to prevent possible loss of steering assistance. In any case the vehicle's steering capacity is not altered.

Remedy

Recalled vehicles will have the power steering earth connection reinforced as necessary.

---

Recalls Number (Vehicles Effected)

R/2006/064 (37)

Manufacturer Reference

Defect

The seat belt locking action may not be as fast as it is designed to be.

Remedy

Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.

---

Recalls Number (Vehicles Effected)

R/2003/130 (201)

Manufacturer Reference

X1W

Defect

There is a possibility that the lower engine mounting point is weak. This may lead to significant engine vibration which in turn could result in the right hand drive shaft coming adrift.

Remedy

Examine and replace the engine support yoke where found necessary.

---

Recalls Number (Vehicles Effected)

R/2002/158 (163)

Manufacturer Reference

XYB

Defect

There is a risk that the tyres may have been damaged during fitting onto the wheel rim at the factory.

Remedy

Replace all five tyres.

---

Recalls Number (Vehicles Effected)

R/2002/021 (41175)

Manufacturer Reference

XUX

Defect

In adverse wet weather conditions water may enter the engine management solenoid valve operating circuit. This could result in engine operating problems and a reduction in power assistance to the brake pedal if the water enters the brake vacuum circuit via the solenoid valves.

Remedy

Recall affected vehicles to examine and if necessary replace the engine management solenoid valves with ones sealed against the ingress of water.

---

Recalls Number (Vehicles Effected)

R/2001/123 (109)

Manufacturer Reference

XTM

Defect

There is a risk of internal cracking of the 4-way brake pipe unions ( non- ABS models) or the 2 x 4 - way brake pipe unions ( ABS models). This could result in a gradual loss of brake fluid and reduced braking efficiency.

Remedy

Recall affected vehicles and replace the four way brake pipe unions.

---

Recalls Number (Vehicles Effected)

R/2000/149 (5835)

Manufacturer Reference

XQW

Defect

Brake vacuum pump drive pin may fail as a result of premature wear. This could result in a loss of power assistance at the brake pedal.

Remedy

Recall affected vehicles to fit a quality assured replacement drive pin to the brake vacuum pump.

---

Recalls Number (Vehicles Effected)

R/1998/111 (828)

Manufacturer Reference

Defect

It has been identified that there is a possibility of premature wear of the handbrake lever ratchet leading to potential disengagement of the handbrake.

Remedy

Recall affected vehicles and where necessary replace the original handbrake with a quality assured unit.